TFS300F.doc v e rs ion 1.4 04.06.2003 vi telefilter filter specification tfs 300 f 1/5 measurement condition ambient temperature: 23 c input pow er level: 0 dbm terminating impedances at f c *) for input: 820 ? ?? - 6,6 pf for output: 670 ? ?? - 6,5 pf ch aracteristics remark: the reference lev e l for the relativ e attenuation a rel of tfs 300f is the minimu m of the pass band attenuation a min . this v a lue is defined as the insertion loss a e . the centre frequency f c is the arithmetic mean v a lue of the upper and low e r frequencies at the 3 db filter attenuation lev e l relativ e to the insertion loss a e . the giv en v a lues for the relativ e attenuation a rel and the group delay ripple hav e to be reached at the frequencies giv en below , ev en if the centre frequency f c is shifted due to the temper ature coefficient of frequency tc f in the operating temperature range and due to a production tolerance for the centre frequency f c . d a t a t y p . v a l u e l i m i t insertion loss a e = a min 13,5 db max. 19 db (at ambient temperature) centre frequency f c - 300 mhz 0,09 mhz (at ambient temperature) passband ripple (p-p) wi t h i n f c 1,2 mhz 0,3 db max. 1,1 db relativ e attenuation a rel f c ... f c 1,2 mhz 0,3 db max. 1,1 db f c 1,2 mhz ... f c 1,65 mhz 2 db max. 3 db f c 2,4 mhz ... f c 6 mhz 45 db min. 40 db f c 6 mhz ... f c 40 mhz 52 db min. 45 db group delay ripple (p-p) wi t h i n f c 1,6 mhz 105 ns max. 200 ns a b solute group delay at f c 1,4 s max. 1,8 s phase ripple (p-p) wi t h i n f c 1,6 mhz 4,5 max. 10 triple transit suppression compared to main signal 50 db min. 37 db return loss w i thin f c 1,6 mhz 15 db min. 10 db operable temperature range - - 40 c ... + 85 c operating temperature range - - 30 c ... + 70 c storage temperature range - - 40 c .....+ 85 c temperature coefficient **) tc -0,04 ppm/k2 - frequency inv e rsion temperature (t o ) 28 c - *) the terminating impedances depend on paras itics and q-v a lues of matching element s and the board used, and are to be understo od as reference v a lues only . should there be additional questions, do not hesitate to ask for an applicat ion note or contact our desi gn team. **) ? f(h z ) = t c f (ppm/k2) x (t-t 0 )2 x f to (mhz) ge ne ra te d: ch ecked / ap p r o v ed : telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS300F.doc v e rs ion 1.4 04.06.2003 vi telefilter filter specification tfs 300 f 2/5 cons truc tion a nd pin conne c t ion (all dimensions in mm) 13 , 31 + / - 0 , 2 0 6, 5 0 + / - 0 , 2 0 1, 80 +/ - 0 .2 1, 9 1 + / - 0 .2 1, 0 2 + / - 0 .2 1, 9+ /-0 . 2 tfs 30 0 f r23 date cod e 1 5 6 10 1 input rf-return 2 ground 3 ground 4 ground 5 output 6 output rf return 7 ground 8 ground 9 ground 10 input date code y ear + w eek n 2001 p 2002 r 2003 ... 50 ? matching circuits l2 o u t put 50 o h m c2 i n put 50 o h m c1 l1 sa w 1, 2, 3, 4, 6, 7 , 8 , 9 10 5 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS300F.doc v e rs ion 1.4 04.06.2003 vi telefilter filter specification tfs 300 f 3/5 stability characteristics after the follow i ng tests, the filter shall meet the w hole specification: 1. shock: 500g, 18 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5g respective ly , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow ): reflow possible: tw ice max.; for temperature conditions, pleas e refer to the attached "air re flow temperature conditions" on page 4; packin g tape & reel: din iec 286 - 3, w i th excepti on of value for n and minimum bending radius; tape ty pe ii , embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters per reel: 1700 reel of empty components at start: min 300 mm reel of empty components at start including leader: min 500 mm trailer min 300 mm d o p o e f w p 1 em bo ss ed c a r r i e r t a pe c o ver t a pe g p 2 b o a o ct d 1 t a pe ( a l l dim e n s io ns in m m ) w : 2 4 0 , 3 p o : 4 0 , 1 d o : 1 , 5 + 0 , 1 e : 1 , 7 5 0 , 1 f : 1 1 , 5 0 , 1 g ( m i n ) : 0 , 6 0 p 2 : 2 0 , 1 p 1 : 1 2 0 , 1 d 1 ( m i n ) : 1 , 5 a o : 7 , 1 0 , 2 b o : 1 3 ,9 0 , 2 c t : 2 1 , 5 0 , 1 a c n w 1 w 2 reel (all dimensions in mm): a : 330 w1 : 24,40 +2,0 w2 (max) : 30,4 n (min) : 60 c : 13 0,5/-0.2 the minimum bending radius is 45 mm. the m ounting surface of the filters faces the bottom side of the embossed carrier tape. markings on the filters can be read if the upper side of the carrier tape is regarded w i th the sprocket holes on its right. telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
tf s 300f . doc v e rs ion 1. 4 04. 06. 2003 vi telefilter filter specification tfs 300 f 4/5 a i r re flow te mpe r a t ure c onditions 1st and 2nd air reflow profile name: pre-heating periods main-heat ing periods peak temperature t e mp eratu r e: 150 c - 170 c over 200 c 255 c 5 c t i m e : 60 sec. - 90 sec. 20 sec. - 25 sec. c h i p - m ount a i r re f l ow pr of i l e ti m e / s e c . t e mper at ur e / c 0 20 40 60 80 100 120 140 160 180 200 220 240 260 0 2 0 4 0 6 0 8 0 100 120 140 160 180 200 220 240 t able for temperature vs. time during the air reflow process t o lerance of temperatures: 5 c time / sec. temperature / c time / sec. temperature / c 0 23 140 160 10 34 150 161 20 46 160 164 30 60 170 170 40 80 180 180 50 103 190 205 60 121 195 230 70 134 200 255 80 143 205 230 90 150 210 205 100 154 215 180 110 156 220 165 120 158 230 140 130 159 240 120 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
tf s 300f . doc v e rs ion 1. 4 04. 06. 2003 vi telefilter filter specification tfs 300 f 5/5 history version reason of changes name date 1.0 generate development specification according to customer requirements. dunzow w. 22.11.2001 1.1 change operating temperature range from [ 0c ...70c ] to [ -30c...70c ]. dunzow w. 30.11.2001 1.2 change of package, insertion loss, requirements in pass band and relative attenuation pfeiffer 30.01.2003 1.3 absolute value of group delay and operable temperature added pfeiffer 26.02.2003 1.4 ty pical values and terminat ing impedances added pfeiffer 04.06.2003 telefilter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
|
